產品概述

120GHz調頻連續波雷達物位計僅需要80ms就能完成一次100m距離范圍完整的測量計算過程。這使得系統可以有更多的時間和資源處理儀表物位應用上的各類事物，比如：概率評估/預測/可信度分析/輸入輸出/通訊等。

DCRD1000B 采用PTFE透鏡天線全密閉灌封設計，并很好地解決了天線近場輻射抑制的結構處理，這使得它有很好的方向性性能，波束角控制在1度以內（批量性產品制造工藝差異，可能會偏差±0.3度左右）。

The 120GHz FMCW Radar level transmitter just need 80ms to finished the distance measurement & calculation process for 100m ranges. This allows the system to have more time and resources to deal with various kinds of things on level application of the instrument, such as: echo signal probability assessment / level prediction / level reliability analysis / input&output/ communication, etc.

DCRD1000B using PTFE lens antenna with hermetic potting design, there is a perfect solution which resolved the antenna near field radiation suppression issues, that makes it has a good directional performance and less 1 degrees beam angle (the mass product manufacturing process differences, may be biased ±0.3 degrees).

應用特點

120GHz調頻雷達物位計，特別適用于高溫、高壓或高粉塵、多攪拌空間的工況環境使用，它滿足了很多需要大量程同時要高精度的測量需求。

120GHz FMCW radar level transmitter, especially be used in the high temperature & pressure,  strong dust & multiple mixing environment, it can satisfy many applications for a large range measurement with high-precision requirements.

技術參數

應    用：固體、固體粉塵工況；

發射頻率：120GHz～130GHz，調頻掃描頻率寬度10GHz；

測量范圍：0.1-50/100/150m；

測量分辨率：0.008m；

測量精度：<±1mm；

發射角度：1°；

過程壓力：-0.1～5MPa； -0.1～32MPa（配石英隔離法蘭盤）；

電纜入口：M20x1.5；

防護等級：IP67；

防爆等級：ExdⅡCT6Gb；

Frequency range: 120GHz~130GHz, Frequency modulation sweep frequency width: 10GHz;

Measuring range: 0.1-50/100/150m;

Measurement resolution: 0.008m;

Accuracy: <±1mm;

Launch Angle: 1°;

Process pressure: -0.1~5MPa;  -0.1~32MPa(With quartz isolation flange);

Cable inlet: M20x1.5;

Protection grade: IP67;

Explosive-proof grade: ExiaExdⅡCT6Gb;

壹、不受大氣降水影響/Not be affected by atmospheric precipitation;

貳、周圍環境溫度-60攝氏度起/The ambient temperature is -60°C;

叁、從貯藏罐外裝置/Being Installed on the outside of tank;

肆、物位計內天線由氟塑料透鏡加熱保護/The antenna inside of the level transmitter is protected by fluoroplastic lens heating;

伍、測量射線窄，便于安裝，測量穩定/The measuring radiation is narrow, easy to install and measurement sensibility;

陸、物位測量準確度，不受容器內溫度限制/The accuracy of the level measurement can't be limited by the temperature of tank;

柒、蒸發作用和灰塵不會影響測量/Evaporation and dust will not affect the measurement;

捌、沸騰液體物位測量/Boiling liquid level measurement;

玖、腐蝕性液體物位測量，無接觸、無腐蝕--穩定測量/Corrosive liquid level measurement, non-contact, non-corrosion, stable measurement;

拾、泡沫、強粉塵液體物位測量/Foam, strong dust level measurement;

透鏡天線雷達液位計/120GHz調頻連續波雷達物位計/120GHz FMCW Radar/DCRD1000B