ABB 3HAB8101-1系統硬件及接口電路

 2.1 ABB 3HAB8101-1控制系統結構

 由80C196KC單片機組成控制系統結構如圖4所示.

圖中ABB 3HAB8101-1接口芯片8155的輸出口PA0～PA7,PB0～PB3經光隔控制短接電容接觸器D1～D12.晶閘管在軟啟動電容時,可能會產生較大的電流,因此必須確保晶閘管每次只啟動一個電容,避免同時投入兩個或兩個以上電容,用接觸器Zi的輔助觸點互鎖,因觸點數量有限,不能全部覆蓋,其互鎖邏輯應滿足:  考慮到在80C196KC系統中互鎖容易實現.根據邏輯要求選擇譯碼器74LS154zui合適,由于74LS154的特性是每次僅輸出一路,用74LS154控制KP的投入接觸器Z[sub]i[/sub],可避免誤動作,而且軟硬件較容易協調,編程方便. 8155的輸出口PC[sub]0[/sub]～PC[sub]3[/sub]對應接到74LS154的A,B,C,D輸入端,這時74LS154控制端全部有效.用PC[sub]0[/sub]～PC[sub]3[/sub]選擇不同的Y[sub]0[/sub]～Y[sub]11[/sub]（74LS154的輸出口）,對應控制Z[sub]1[/sub]～Z[sub]12[/sub].當不需要輸出時（即Y[sub]0[/sub]～Y[sub]11[/sub]不輸出）,僅令PC[sub]0[/sub]=PC[sub]1[/sub]=PC[sub]2[/sub]=PC[sub]3[/sub]=1,選中Y[sub]15[/sub]輸出即可.

 2.2 ABB 3HAB8101-1相位檢測電路 系統能準確可靠地獲取功率因數cosφ是非常重要的,φ為電流落后或超前電壓的角度.相位φ檢測電路原理如圖5所示.

ABB 3HAB8101-1用泰勒展開式求cosφ值,顯然cosφ=1-（φ[sup]2[/sup]/2!）+（φ[sup]4[/sup]/4!）-（φ[sup]6[/sup]/6!）能保證系統的精度要求.亦可采用查表法計算cosφ值.在計算出cosφ的值后,還要進一步確定φ的方向,這可由相應的硬件與軟件配合完成.

OMRON PLC CPM2A-30CDR-A, !

SCHUMACHER ASSY.1730-3002 PCB CARD

OLYMPUS OPTICAL BRUSHLESS DC SERVO MOTOR BC30CA52CABAN

SIEMENS SIMATIC S5 6ES5 943-7UB11

SYSTEM BASE MULTI-4/ISA VER 5.2 M2 BOARD

HD HARMONIC SERVO ACTUATOR RH-11-6001-E100DOM-SP,ENCODER-02A 1000P/R #1

HAKKO TOUCH SCREEN V706CD DC24V 0.6A SERIAL USB PORT TESTED WORKING #1

HAKKO TOUCH SCREEN V706CD DC24V 0.6A SERIAL USB PORT TESTED WORKING #2

COPLEY CONTROLS CORP DC POWER AMPLIFIER MODULE 230 MASTER 230-13A

SIEMENS SIMATIC,6ES5-470-4UB12

VEXTA,ORIENTAL,HARMONIC GEARED STEPPING MOTOR,DRIVER,CSD5807N-P,PH544HG2-NB-A10

VEXTA,ORIENTAL,HARMONIC GEARED STEPPING MOTOR,DRIVER,CSD5807N-P,C4773-90215HGE

YAMATAKE DISTRIBUTED I/O MODULE HD-CXAD20

MITSUBISHI INVERTER FR-Z024-0.75K

SIEMENS SITOP POWER 30 6EP1437-1SL01

SMC FLOW SWITCH FOR WATER PF2W740-N04-67 LOT OF 2

KITZ SCT DIAPHRAGM VALVE PCTFE-SEAT SCV 316L 10K-1/2" (3/8") LOT OF 2

ALLEN-BRADLEY OEMAX NXI/O-DNA CAT NO. NXIO-END

OMRON SYSMAC PLC CPM1A, 20EDR